Feasibility of primary copper smelter weak sulfur dioxide stream control

  • 520 Pages
  • 3.59 MB
  • 9575 Downloads
  • English

Industrial Environmental Research Laboratory, Office of Research and Development, U.S. Environmental Protection Agency, Available to the public from the National Technical Information Service , Cincinnati, Springfield, Va
Air pollution control industry, Smelting, Sulfur di
Statementby I.J. Weisenberg ... [et al.]
SeriesResearch reporting series -- EPA-600/2-80-152
ContributionsWeisenberg, I. J, Pacific Environmental Services, Industrial Environmental Research Laboratory (Cincinnati, Ohio)
The Physical Object
Paginationxx, 520 p. :
ID Numbers
Open LibraryOL14213404M

EPA/ July FEASIBILITY OF PRIMARY COPPER SMELTER WEAK SULFUR DIOXIDE STREAM CONTROL by I.J. Weisenberg T. Archer F.M.

Description Feasibility of primary copper smelter weak sulfur dioxide stream control PDF

Winkler T.J. Browder A. Prem Pacific Environmental Services, Inc. Santa Monica, California Contract No. Feasibility of primary copper smelter weak sulfur dioxide stream control.

Cincinnati: Industrial Environmental Research Laboratory, Office of Research and Development, U.S. Environmental Protection Agency ; Springfield, Va.: Available to the public from the National Technical Information Service, (OCoLC) Material Type. Feasibility of Primary Copper Smelter Weak Sulfur Dioxide Stream Control: Volume 1 - Ebook written by.

Read this book using Google Play Books app on your PC, android, iOS devices. Download for offline reading, highlight, bookmark or take notes while you read Feasibility of Primary Copper Smelter Weak Sulfur Dioxide Stream Control: Volume 1.

The history of attempts to control sulfur oxide emissions from copper smelting, in order to reduce air pollution, goes back at least years.2A Manufacture of sulfuric acid from copper smelter gases was undertaken in Great Britain at least years ago, partly in response to a need to control air pollu.

Copper Smelter –II will be located in ha. and the Land kept in hand in Zone –A for future purpose is ha. The location map and study area of km radius of the plant is shown in Figure-1 and Figure-2 respectively.

Environmental Setting of the Plant Site. Smelter plumes transport an array of toxic metals in addition to SO2 and continued monitoring to mitigate health and environmental impacts is recommended. Citation: Carn, S. A., A. Krueger, N.

Download Feasibility of primary copper smelter weak sulfur dioxide stream control EPUB

Krotkov, K. Yang, and P. Levelt (), Sulfur dioxide emissions from Peruvian copper smelters detected by the Ozone Monitoring Instrument. Development Feasibility Of Primary Copper Smelter Weak Sulfur Dioxide Stream Control' ' test methods for evaluating solid waste volume ic may 2nd, - united states environmental protection agency office of solid waste and emergency response washington dc november sw third edition solid waste test methods for evaluating solid.

Primary Copper Smelting General1 Copper ore is produced in 13 states. InArizona produced 60 percent of the total U. ore. Fourteen domestic mines accounted for more than 95 percent of the megagrams (Mg) ( millon tons) of ore produced in Copper is produced in the U.

primarily by pyrometallurgical smelting. This chapter introduces the fundamentals of matte smelting and the influence of process variables. Matte smelting is the most common way of smelting copper–iron sulfur concentrates. The primary purpose of matte smelting is to turn the sulfide minerals in solid copper concentrate into three products: molten matte, molten slag, and offgas.

SOURCE U S Congress, General Accounting Office,Air Pollution Sulfur Dioxide Emissions from Nonferrous Smelters Have Been Reduced, report to the Chairman, Subcommittee on Oversight and Investigations, Committee on Energy and. techstreet com. Feasibility Of Primary Copper Smelter Weak Sulfur Dioxide.

TECHNICAL REQUIREMENTS AND SPECIFICATIONS. Chemflake Special Jotun. Standard Recommended Practice Discontinuity Holiday.

NACE International SP formerly RP Holiday Inspection Testing Coatings High Voltage Voltage. REQUEST FOR PROPOSAL Seattle gov Home. Feasibility of primary copper smelter weak sulfur dioxide stream control. emissions of SO2 from primary copper smelters in the U.S. is the reverberatory furnace because gas strength is too low.

Feasibility of primary copper smelter weak sulfur dioxide stream control. of SO2 from primary copper smelters in the U.S. is the reverberatory furnace because gas strength is too low for. FEASIBILITY OF PRIMARY COPPER SMELTER WEAK SULFUR DIOXIDE. STANDARD PRACTICE CONTROL OF EXTERNAL CORROSION ON.

UFDC UFL EDU lttr 1 US Department of Transportation April 6th, - with NACE RPO Weather permitting a single confirmatory dig will take place within ninety 90 days of our receipt of the Proposed Compliance Order.

Copper Smelting residues requires preparation of the scrap (such as removal of insulation, etc.) prior to feeding into the primary process.

Electric arc furnaces using scrap as feed are also common. Waste Characteristics Principal air pollutants emitted are sulfur dioxide (SO2) and particulate matter from the processes. Sulfur dioxide is another by-product or co-product of the smelting process.

The sulfur dioxide is captured and converted to sulfuric acid at all the smelters in co-located acid plants. Input substitution possibilities are limited. primary copper smelter production in is reported as.

6 TABLE ANODE COPPER PRODUCTION AND CAPACITY. (a) A primary copper, lead, zinc, molybdenum, or other nonferrous smelter is eligible for an NSO if it meets the following conditions: (1) The smelter was in existence and operating on August 7, ; (2) The smelter is subject to an approved or promulgated sulfur dioxide (SO 2) State Implementation Plan (SIP) emission limitation which is adequate to ensure that National Ambient Air Quality.

On this page: Rule Summary; Rule History; Rule Summary. These standards, which were promulgated on Janurequire new and modified Primary Copper Smelters to limit particulate matter emissions to 50 milligrams per dry standard cubic meter (mg/dscm), maintain opacity at or below 20%, and limit sulfur dioxide emissions in the gases released from the stacks (from roasters, smelting.

Feasibility of primary copper smelter weak sulfur dioxide stream control. Final report. The major source of uncontrolled emissions of SO2 from primary copper smelters in the U.S. is the reverberatory furnace because gas strength is too low for direct processing in a sulfuric acid plant, the accepted control approach in this industry.

The smelter's net smelting charge is equal to the combined world smelting charge, adjusted to the U.S. producer price for copper (i.e., the export forecast charge plus the U.S. producer price premium), and the transportation cost between the mine and a Far East smelter, minus the cost of transporting the concentrate between the mine and the.

Corrpro Aegion. Corrosion Control Project SlideShare. Mechanisms Of Scale Formation And Inhibition Mineral. Standard Practice Control Of External Corrosion On. Control Of External Corrosion On Underground Or Submerged.

Feasibility Of Primary Copper Smelter Weak Sulfur Dioxide. 44 Church Directory DruryWriting. Approximately 50% of all primary copper in the world is already produced with the technology, and the percentage is on the rise.

It is estimated that without flash smelting, the annual world sulphur dioxide emissions would be 5 to 10 million tonnes higher.

A Big Step for Copper Smelting: Flash Converting. Methods of Copper Smelter. Based on the source of copper, copper smelter method is divided into two categories: primary copper smelter and secondary copper smelter.

If the source of copper material came from earth (ore), then it is primary copper smelter. But, if the source came from scrap (pipe, wire, bushing, bearing, etc), then it is. Mortality for three groups of ICD codes covering acute, chronic, and malignant respiratory diseases were studied for adult white women in communities near or adjacent to primary copper smelting facilities in the United States between anda period when.

Final Report Contract CPA FEASIBILITY STUDY OF NEW SULFUR OXIDE CONTROL PROCESSES FOR APPLICATION TO SMELTERS AND POWER PLANTS Part I: The Monsanto Cat-Ox Process for Application to Smelter Gases Prepared for: U.S. DEPARTMENT OF HEALTH, EDUCATION, AND WELFARE NATIONAL AIR POLLUTION CONTROL ADMINISTRATION DURHAM, NORTH.

Nonferrous metals, including copper, nickel, zinc, lead, and molybdenum, are mined as metal sulfides, and the metal liberated by roasting the sulfides in a smelter oven. The smelter oven is fed with air or oxygen-enriched air and produces an offgas containing large amounts of sulfur dioxide.

The exact compositions of commercial catalysts for the oxidation of sulfur dioxide are proprietary. Sulfuric acid is made from sulfur trioxide by reacting exit gas from the catalytic oxidation with the water in % sulfuric acid.

The double-contact acid-making plant is the most common flowsheet used for capture of sulfur dioxide. The Miami copper ISASMELT furnace was designed to treatt/y (, short tons per year) of copper concentrate, a treatment rate that was constrained by the capacity of the sulfuric acid plant used to capture the sulfur dioxide from the smelter’s waste gases.

Lung function among employees of a copper mine smelter: lack of effect of chronic sulfur dioxide exposure. Federspiel CF, Layne JT, Auer C, Bruce J. Lung function among white male employees of a southeastern Tennessee copper mine/smelter operation was compared according to smoking history and occupational experience.

smelting, where sulfur from the bauxite ore and anodes can evolve as sulfur dioxide gas in the smelting process. Now the requirement for SO 2 emissions reduction has become a strong initiative in the aluminum smelting industry.

Other metals industries, including copper, nickel, and lead producers, have been capturing and treating. tering, into a primary smelter. Lead concentra-tions can be 50–70%, and the sulfur content of sulfidic ores is in the range of 15–20%.

Zinc con-centration is in the range of 40–60%, with sulfur content in sulfidic ores in the range of 26–34%. Ores with a mixture of lead and zinc concentrate usually have lower respective metal concentra.SP Control of External Corrosion on Metallic.

Pipeline and Hazardous Materials Safety Administration.

Details Feasibility of primary copper smelter weak sulfur dioxide stream control PDF

44 Church Directory DruryWriting. Feasibility Of Primary Copper Smelter Weak Sulfur Dioxide. Standard Recommended Practice Control of External. TABLE OF CONTENTS Maine gov. PA Bulletin Doc No 01 f. ufdc ufl edu.nonferrous metals, including copper, nickel, zinc, lead, and molybdenum, are mined as metal sulfides, and the metal is liberated by roasting the sulfides in a smelter oven.

the smelter oven is fed with air or oxygen-enriched air and produces an offgas containing large amounts of sulfur dioxide. membrane technology and research, inc., has.